Install Shower Pan Over Concrete Floor

Then you ll need a new shower pan.

Install shower pan over concrete floor.

How to install a shower base on the concrete floor has been a question in many people s mind. Pour a layer of mortar over top of the shower membrane and form the slope down towards the drain hole. Many homeowners choose a shower and thus a shower pan because you can t have one without the other over a bathtub when renovating in order to increase the available floor space and make the. Use the level to make sure all sides of the pan slope toward the drain.

Also make sure your floor is pre sloped before installing the rubber liner in the following steps to prevent. All these come in one piece. Waterproof the shower pan. Mark the center of each wall stud on the shower pan rim.

The shower in this project will be flush with the side of the whirlpool bath so the frame needed to extend under the tub overhang. You will later screw the shower pan into the. Ideally you re putting it in an area where a drain has already been roughed in. In addition shower bases come in various shapes and designs.

Pre drill holes through the shower pan rim at the marked locations. Ideally you ll already have a drain roughed in with the pipe sticking a few inches above the floor. Get a professional plumber to rough in the shower drain before starting the concrete installation. If you want to install a shower over a concrete floor a fiberglass shower stall will work just fine.

Pour mud into the shower pan mixing it with a trowel as you go to get rid of air bubbles. The roofing paper provides cushion between the concrete and the vinyl membrane which is critical. Mark the outline of the shower pan on the subfloor using pencil or a chalk line. Shower bases are easy to fix easy to clean fewer chances of leakages.

Paint over the entire pan including corners nooks and the perimeter with a liquid waterproofing product. Easy by brewing up a nice hot cup of joe and w. Leave the mortar to cure. Installing a base on concrete.

Test fit the shower pan to confirm the drain opening fits over the drain hole in the floor. What do you do. Wait three days for the mud to dry and cure before waterproofing it. Where do you start.

When you re installing a fiberglass or acrylic shower liner enclosure not to be confused with a shower curtain and base over a concrete floor special considerations should be taken to minimize leaks. Otherwise you have to break through the concrete to run a new line for a shower stall installation. If you use a sheet membrane you will have to install a layer of roofing paper first and then install the vinyl membrane. The shower base can be made of fiberglass acrylic and ceramic among others.